Toyota Starlet Wiring Diagram Download

TOYOTA STARLET EP82 Wiring connections, Connector IDs & Loom Layouts Rev 1.2 – Last Updated October 2011 Author & Copyright : Alan Mears © Location : Perth, Western Australia Contact Email : [email protected] Online Forums User Name : Mearcat
This document details a large amount of wiring information which I could ascertain from the two main wiring looms (Cabin & Engine Bay) that was provided with a 1991 (Gen 1) EP82 Toyota Starlet GT (4E-FTE) front cut, however much of the wiring layout and information will be appropriate to later Toyota Starlet models (with eg slightly different connectors or wiring colours). Please note that there are no specific details of wiring connections and connectors in the doors, nor rear wiring loom of the car - due to those parts of the car not included with the front cut. The front cut was a Manual Transmission 4E-FTE which was not fitted with TEMS or ABS, so no specific details of those components could be provided. To advise of any corrections, please contact me on the above email address.
Table of Contents Page 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
Contents Wiring Loom Layout (To Scale) Connector ID Quick Reference Table Connectors 1-15 (Cabin Loom) Connectors 16-30 (Cabin Loom) Connectors 31-42 (Cabin Loom) Connectors 43-57 (Engine Bay Loom) Connectors 58-72 (Engine Bay Loom) Connectors 73-90 (Engine Bay Loom) Connectors 91-97 (Engine Bay Loom) Connector Pinouts & Conduction Details Relay, Fuse & Temperature Sensor IDs Relay Connection & Pin Details Instrument Cluster Connections & PCB Tracks Instrument Cluster Wiring Diagram ECU Pinout Details ECU Wiring Diagram Power & Switch Wiring Diagram A/C Condenser & Radiator Fan Relay Configurations
Page 1 of 19
90
87
88
G
96 97
89
Passengers Side
72
66
71
65
83
69
92
70
68
84
Box above inlet manifold
Fuse & Relay Box 54
58
85 Batt
53
Diag.
73
74
77
75
59 78
63 55
Drivers Side
G
67
A/C Relays
94
93
91
86
57
82
80
79
76
95
81
G
60 61
56 62 51 Engine Bay Loom 0002
50
52
64
49
ECU
43 44
48 46 47 2
7
Additional 5 Connectors in base of fuse box
39 36
35 33
40
8
G
Cabin Loom 0001
37
45
41 42
3 To LHS Door
Fuse Box
38
29
34 G
32
26
31 19 9
24
20 6
10
5 1
G
Main Battery Ground/Earth Mount Rubber Firewall Grommet
22
14
15
21 17
13 ECU
12
23
28 27 To RHS Door
16
11
Front wiring loom layout Scale 1:10 when printed on A4 Sheet Scale 1:5 when printed on A3 Sheet Batt
30
25
4
18 Page 2 of 19
Connector ID Quick Reference Table # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42
Cabin Loom Circuit Opening Relay Fan/Blower Fan/Heater Assembly TEMS Computer / Module LHD Speaker (Cabin) Interior Light Door Switch (Left Door) To Power Windows (Left Door) To Power Mirrors (Left Door) Roof / Dome / Interior Light Heater & A/C Dash Controls (Fan, Vent Direction, Recirc/Fresh Air) Air vent Direction Motor ECU Cigarette Lighter Stereo Rear plug Clock (Upper Dash) Instrument Cluster (Blue Connector) Instrument Cluster (White Connector) Instrument Cluster (Boost Pressure Gauge & Lo/Hi Light) Turn Signal / Indicator Flasher Module Relay Light Reminder Module Brake Pedal Switch Door Control Module RHS Speaker (Cabin) Fog Light On/Off Switch TEMS Switch Relay (hardwired) Power Windows To Power Windows (Right Door) To Power Mirrors (Right Door) Interior Light Door Switch (Right Door) To Rear Wiring Loom Power Window Control Buttons Hazard Light Button Lo/Hi Boost Button Rear Window Demister Button Power Mirrors Adjustment Buttons Ignition Barrel Steering column combination switch (Rear Wiper) Steering column combination switch (Front Wipers) Steering column combination switch (Lights & Indicators) Foot/Lower Air Direction Motor To Engine Bay Loom (Connector 46) To Engine Bay Loom (Connector 47)
# 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84
Engine Bay Loom To Cabin Fuse Box To Cabin Fuse Box To Cabin Loom To Cabin Loom (Connector 41) To Cabin Loom (Connector 42) HVAC Module Windscreen Wiper Motor (Front) Sub-harness Connector Vacuum Switch Valve Idle up Valve Diagnostics Port (Hardwired) Reverse Switch on Gearbox Ignitor Coil Unknown Throttle Position Sensor Boost Pressure / MAP Sensor Starter Motor Solenoid (Main Voltage) Starter Motor Solenoid (Trigger) Alternator Unknown ECU Oil Pressure Sender Catalytic Converter Overheat Sensor Oxygen / O2 Sensor Coolant Sensor (To HVAC module) Coolant Switch (For Radiator Thermofan) Coolant Temperature Sensor (For Dash Temp Gauge) Coolant Temperature Sensor (To ECU) Distributor Injector 4 Injector 3 Injector 2 Injector 1 Inlet Manifold Temperature Sensor Idle Adjust Valve Vacuum Solenoid Valve Knock Sensor Low Level Brake Fluid Reservoir Switch Unknown Front-Left Indicator Front-Left Fog Light
# 85 86 87 88 89 90 91 92 93 94 95 96 97
Engine Bay Loom A/C Pressure Switch Front-Left Main Light Front-Left Park Light Radiator Fan A/C Condenser Fan Ambient Temperature Sensor Horn A/C Compressor Front-Right Main Light Front-Right Park Light Windscreen Washer Pump Front-Right Indicator Front-Right Fog Light
Connectors are referenced in the following pages with a ‘C-‘ prefix eg C-12 for Connector 12
Page 3 of 19
1. Circuit Opening Relay
3. Fan/Heater Assembly
2. Fan / Blower
4. TEMS Computer / Module
2
4
5. LHS Speaker (Cabin)
4
3
1
2
1
1 5 1 3
4
2
2
3
6
5
1. Fuel Pump 12V (Blue-White) 2. 12V via EFI Relay & ECU ‘BATT' (Black-Red) 3. ECU ‘STA'; Connector 36 ‘ST1' & Starter Motor Solenoid (Black) 4. ECU ‘FC' (Green) 5. GND (White-Black)
1. Dash Fan Switch via C-10 (Blue-Red) 2. From ‘Heater' Fuse (Blue-White)
6. Interior Light Door Switch (Left Door)
7. To Power Windows (Left Door)
1
2
3
4
1. Blue-Red 2. Blue-Yellow 3. Blue-Black 4. White-Red All wires from C-10 (Dash Buttons)
8. To Power Mirrors (Left Door)
1
2
4
5
8
7
9
1. ECU CON-2 Pin 12 (Yellow-Black) 2. Green-White 3. Green-Yellow 4. From ‘Ignition' Fuse (Blue-Green) 5. Light Green 6. GND (White-Black) 7. To Dash LED C-17 A5 (Pink-White) 8. Green-Red 9. To Dash LED C-17 A7 (Pink-Black) 9. Roof / Dome Interior Light
1
2
3
4
To C-14 Pink & Dark Pink
10. Heater & A/C Dash Controls (Fan, Vent Direction, Recirc)
3
5
To Roof Mounted Light C-9 (Red-White)
1. Red 2. Green 3. Blue-Yellow 4. Blue-Red 5. Blue-Green (all thicker gauge wire – to C-22)
1. Light Green 4. Green-Black 1,2,3 to C-35 4,5, to C-31
11. Air Vent Direction Motor
12. ECU
13. Cigarette Lighter Wires (no connectors shown)
2. Pink-Black 5. Red-Black
3. Pink-White
1. Blue-Green 2. White-Black 3. To C-6 (Blue-Yellow) 4. From ‘Dome' Fuse (Red-White) 1 & 2 not connected (for sunroof?) 14. Stereo Rear Plug
6
1
2
15. Clock (Upper Dash)
5
4 3
ECU Connector ‘CON-2' All wires lead to C-10
GND (White-Black) 12V Acc (Grey) From ‘Radio' Fuse
1. Left Speakers (Pink & Dark Pink) 2. Right Speakers (Light Green & Blue) 3. GND (Brown) 4. Park lights lighting signal (Green) 5. 12V Constant from ‘Dome' Fuse (BlueYellow) 6. 12V Acc From ‘Radio' Fuse (Grey)
1
2
3
4
1. Park lights lighting signal (Green) 2. 12V Constant from ‘Dome' Fuse (Blue-Yellow) 3. GND (White-Black) 4. 12V Acc (Grey) From ‘Radio' Fuse
Page 4 of 19
16. Instrument Cluster
18. Instrument Cluster (Boost pressure Gauge (Lo/Hi)
17. Instrument Cluster
19. Turn Signal / Indicator Flasher module
20. Relay Light Reminder module
2 1 2
1
4 1 For Connections, See Page 15
For Connections, See Page 15
21. Brake Pedal
22. Door Control module
1
2
3
4
3 3
1. From ‘Instrument/Dash' Fuse (Red-Blue) 2. Hi/Lo Boost Mode from C-59 (Light Green) 3. Boost Press Signal C-33 (Light Green-Red) 4. GND (Brown)
1. GND (White-Black) 2. ‘F' C-32 (Light Green) 3. ‘TB' C-32 & C-39 (Green-Blue)
1. 12V from ‘Dash' Fuse (Red-Blue) 2. 12V Acc from ‘Radio' Fuse (Grey) 3. Park lights lighting signal (Green) 4. Door Switch C-29 (Red-Green)
23. RHS Speaker (Cabin)
24. Fog Light On/Off Switch
25. TEMS Switch
Pedal Switch N/O (Normally Open)
2 1
2
1
1. 12V from ‘Stop Lights' Fuse (Green-Red) 2. To rear of car via C-30 (Green-White) Pedal Switch N/O (Normally Open)
26. Relay (hardwired – no connector) – for power windows
Top Row 1-4 Bottom Row 5-10 1. Red-Blue 2. Red-Green 3. Red (Thicker gauge) 4. Green (Thick gauge) 5. From Power Window Fuse (Blue Thick gauge) 6. Green-Red 7. Red-White 8. Red-Green (From ‘Dash' Fuse via Diode) 9. Green (Thick gauge) 10. GND (White-Black Thick gauge) 27. To Power Windows (Right Door)
1
2
To C-14 Light Green & Blue
2
1. To Fog Lights (Red) 2. ‘T' C-39 (Green)
1. C-4 Light Green 2. From ‘Ignition‘ Fuse (Blue-Green)
Switch N/O (Normally Open)
28. To Power Mirrors (Right Door)
29. Interior Light Door Switch (Right Door)
30. To Rear wiring loom
3
1-4 1
1
2
2
5-9
4 10-13
3-6 3
4
5-9
30Amp Fuse : 1. Ignition ‘AM1' (White) 2. To C-22 (Blue – Thicker gauge) Relay Coil : 3. From C-22 (Blue-Green) 4. GND (White-Black) Relay Contact Wires : 5. From C-22 (Blue – Thick gauge) 6. From C-27 (Blue-Green – Thick gauge)
1. Blue-Red (Thicker gauge) 2. White-Black (Thicker gauge) 3. Green (Thicker gauge) 4. Blue-Yellow (Thicker gauge) 5. Green-Red 6. Red-White 7. Red (Thicker gauge) 8. Green (Thicker gauge) 9. Blue-Green (Thicker gauge) All wires to C-22
1. Light Green-Black 2. Blue-Black 3. Light Green-Red 4. Light Green-Black 5. Light Green 1,2 to C-31 3,4,5 to C-35
14-19
5 Light Reminder Module & Dome Light via Diode To C-20 (Red-Green)
1. Red-Blue 2. Green-Black 3. Green-Yellow 4. Green-Yellow 5. Red-Yellow 6. Yellow-Red 7. Black 8. Green 9. Green-Red 2 Dot 10. Blue-White 11. Green-White 12. Red-Black 13. Blue-Red 14. Yellow-Black 15. Yellow-Blue 16. Blue 17. Blue-Black 18. Blue-Yellow 19. Green-red 1 Dot For Connections, See Page 11
Page 5 of 19
31. Power Window Control buttons
1
32. Hazard Light Button
34. Rear Screen Demister Button
2 2
1
1 1
5-10
2
3-8 1. Red-Black 3. Blue 5. Green-Black 7. Dark Pink 9. Blue-Yellow
2. Light Green 4. Light Green-Black 6. Pink 8. From ‘Radio' Fuse (Grey) 10. Blue-Black
36. Ignition Barrel
2
1 1. Park lights lighting signal (Green) 2. GND (White-Black) 3. ‘TL' (Green-Black) 4. ‘TR' (Green-Yellow) 5. ‘F' (Light Green) 6. ‘B2' From ‘Haz/Horn' Fuse (Green-White) 7. ‘TB' (Green-Blue) 8. ‘B1' From ‘Turn Signals' Fuse (Red-Blue) 37. Steering column combination switch (Rear Wiper)
1. GND (Brown) 2. ECU ‘BC' (Light Green-Red) & Dash boost indicator via C-18
38. Steering column combination switch (Front Wipers)
1
1. GND (White-Black) 2. From ‘Rear Demister' Fuse (Light Green) 3. To Demister via C-30 (Black)
1. RHS Mirror (Light Green-Red) 2. GND (White-Black) 3. From ‘Radio' Fuse (Grey) 4. RHS Mirror (Light Green-Black) 5. LHS Mirror (Pink-Black) 6. LHS & RHS Mirror (Light Green) 7. LHS Mirror (Pink-White)
39. Steering column combination switch (Lights & Indicators)
40. Foot/Lower Air Direction Motor
2
2
5
3 1
1
4
2
6 3
4
3
4 3
All thick gauge wires lead to Cabin Fuse Box 1. ‘AM2' (White-Red) 2. ‘IG2' (Black-Red) 3. ‘IG1' (Black-Yellow) 4. ‘ACC' (Blue-Red) 5. ‘AM1' (White) 6. ‘ST1' ECU ‘NSW' & ECU ‘STA' (Black-White)
1. ‘I' C-30 (Blue-Yellow) 2. ‘E' GND (White-Black) 3. ‘+1' C-30 (Blue-Black) 4. ‘W' C-95 (Blue-White)
Missing pin (top left – N/C) is ‘ST2'
See Page 11 for Conductions
4
5
1. ‘+1' C-49 (Blue-Black) 2. ‘+2' C-49 (Blue-Orange) 3. ‘EW' GND (White-Black) 4. ‘W' C-95 Washer (White-Blue) 5. ‘+B' C-49 (Blue) From ‘Wipers' Fuse 6. ‘+S' C-49 (Blue-Yellow) See Page 11 for Conductions
See Page 11 for Conductions
41. To Engine Bay Loom
3-7
3
2
1
3
35. Power Mirrors adjustment button(s)
4
3
2
33. Lo/Hi Boost Button
6
5-10 1. ‘E' GND (White-Black) 2. ‘TL' Turn Signals Left (Green) 3. ‘TB' Turn Signals 12V (Green-Blue) from ‘Turn Signals' fuse 4. ‘TR' Turn Signals Right Green-Yellow (1 Dot) 5. ‘HU' Headlights High Beam (Red-Yellow) 6. ‘RF' ECU ‘ELS' (Red-Green) 7. ‘HL' Headlights Low Beam (Red-White) 8. ‘TI' To Park Lights (Green) 9. ‘BO' From ‘Tail Lights' Fuse (Green-White) 10. ‘HO' Horn (Green-Yellow 2 Dot) – Horn button shorts this pin to GND See Page 11 for Conductions
1
2
All wires lead to C-48 1. Dark Pink-Green 2. Dark Pink-Red 3. Red-Blue
42. To Engine Bay Loom
Page 6 of 19
43. To Cabin Fuse Box
44. To Cabin Fuse Box
‘AM1' Single thick gauge wire – 12V (White)
Ignition wiring from Connector 36
48. HVAC module
49. Front Windscreen Wiper Motor
1
45. To (side of) Cabin Fuse Box
46. To Cabin Loom
47. To Cabin Loom
Bypasses fuse box and connects to Cabin loom 50. Sub-harness connector to sensors (mounted above Ignitor on firewall)
51. RHS Sensor above Ignitor (Vacuum switch valve) Used by HVAC module
52. LHS Sensor above Ignitor (Idle up Valve) Used by HVAC module
1
2
1
1 2 3
3 1. ECU ‘AC2' 2. ECU ‘AC1' 3. ECU ‘ACT' Wires connect to C-40 C-51 C-52 C-68 C-85 C-90 C-92 53. Diagnostics Port (hardwired – no connector) For Connections, See Page 11
3
4
3
2
1. Blue-Orange (Fast wiper speed) 2. Blue-Black (Slow wiper speed) 3. Blue-Yellow (Intermittent/Park) 4. Blue (12V Constant - From ‘Wipers' Fuse) All wires to C-38. GND on wiper motor case. 54. Reverse Switch on gearbox
1
To sensors To Main loom C-51 & C52 Green -------- 1 --- Green-Blue Black ---------- 2 --- Black-Yellow Grey ---------- 3 ----- Green-Red 55. Ignitor
1
1
2
2
3
4
2
1. To Reverse Light (Red-Black) 2. 12V from ‘Instrument/Dash Cluster' fuse (Red-Blue)
5
2
1
2
1. GND (Black-Yellow) 2. To HVAC Module C-48 (Green-Blue)
1. GND (Black-Yellow) 2. To HVAC Module C-48 (Green-Red)
56. Coil (Under Ignitor)
57. Unknown
1
1
2
2 1. ECU ‘IGF' (Grey-Black) 2. ECU ‘IGT' (Light Green-White) 3. ‘IG2' Ignition (Black-Red) 4. Diagnostics Socket ‘IG-‘ (Black) 5. Pin 2 on Coil C-56 (Black-White)
1. ‘IG2' Ignition (Black-Red) 2. Pin 5 on IgnitorC-55 (Black-White)
1. ‘IG2' Ignition (Black-Red) 2. ECU CON-2 ‘IPV' (White-Black) ‘IPV' is Vacuum Switching Valve on Gen2 EP82 models (unused on Gen 1 EP82)
Page 7 of 19
58. Throttle Position Sensor
59. Boost Pressure / MAP Sensor
60. Starter Motor Solenoid (Main Voltage)
61. Starter Motor Solenoid (Trigger)
62. Alternator
1
4
3 3
2 1
2 1
2
3
1. ECU ‘IDL' (Yellow-Red) 2. ECU ‘E2' (GND - Brown) 3. ECU ‘PSW' (Yellow-Green)
1. ECU ‘E2' (Brown) 2. ECU ‘PIM' (Green) 3. ECU ‘VCC' (Green-Red)
63. Unknown
64. ECU
1
Ignition ‘ST1' on Ignition C-36 (Black-White) Single black wire (heavy gauge) – connected directly to Battery
65. Oil Pressure Sensor
2
1
2
Connector CON-1 Same wires as C-82 1. Green-Red 2. Green-Yellow (To Rear of Car C-30) 68. Coolant Sensor (To HVAC module)
66. Cat Converter Overheat sensor
69. Coolant Switch – For Radiator Thermofan
Single wire (Yellow) Connects to Instrument cluster C-17 A8
70. Coolant Temperature Sensor (To Instrument cluster temperature gauge)
1. From ‘Instrument/Dash Cluster' Fuse (RedBlack) 2. Connection to Battery via AM1 fuse (White) 3. To C-17 A4 Battery Light in instrument cluster (Yellow-Black) 4. Connection to Battery via AM1 fuse (White) 67. Oxygen Sensor
1. ECU CON-2 Pin 3 ‘CCO? ' (Grey-Green) 2. Ground (Brown)
ECU ‘OX' (White)
71. Coolant Temperature Sensor (To ECU)
72. Distributor
3 2
1
4
2
1
Connector on short (10cm) sub-harness Wire in White in sub-harness; Blue-Yellow in main loom To HVAC module C-48
To C-85 (Light Green) Temperature Switch Normally Closed (N/C)
To Instrument cluster C-17 A12 (Yellow-Green)
1. GND – ECU ‘E2' (Brown) 2. ECU ‘THW' (Green-Black)
1. ECU ‘NE' (White-Blue) 2. ECU ‘G1' (Orange-Blue) 3. ECU ‘G2' (Blue-Green) 4. ECU ‘G-‘ (Blue-Yellow)
Page 8 of 19
73-76. Injectors
77. Inlet Manifold Temperature Sensor
78. Idle Adjust Valve (mounted to side on inlet manifold)
79. Vacuum Solenoid Valve (Controls pressure to wastegate actuator)
80. Knock Sensor (Rear of block)
1
2 1
2
2
1
1. Injector 1 & 3 ECU ‘#10' (Green) Injector 2 & 4 ECU ‘#20' (Yellow) 2. Ignition IG2 (Black-Red)
1. Sensor GND ECU ‘E2' (Brown) 2. ECU ‘THA' (Light Green-Black)
81. Low Level Brake Fluid Reservoir Switch
82. Unknown (in front of brake fluid reservoir)
2 1
1. ECU ‘DISC' (Pink-Black) 2. 12V via EFI Relay (Black-Red)
1. 12V via EFI Relay (Black-Red) 2. ECU ‘VSV1' (Pink-White)
83. FL Indicator
84. FL Foglight
ECU ‘KNK' (Black)
85. A/C Pressure Switch Mounted in A/C Piping (no connectors shown). Switch Normally Closed (N/C)
1
Light Green – C-69 (Coolant Sensor) Light Green-Red – to ‘Cooling Fan' relay, ‘A/C Fan No. 2' relay & HVAC Module C-48
1
2
2
1
2
2 1
1. Instrument cluster C-17 A3 (Yellow-Red) 2. GND (White-Black) N/O circuit. At low fluid level, circuit is shorted. 86. FL Main Light/High Beam
Same wires as C-63 1. Green-Yellow 2. Green-Red
1. GND (White-Black) 2. ‘TL' (Green-Black)
1. 12V From Fog Light Switch (Red) 2. GND (White-Black)
87. FL Park Light
88. Radiator Fan
89. A/C Condenser Fan
90. Ambient Temperature Sensor (To HVAC module)
1
2
1 2
3
1. From ‘Headlights Left' Fuse (Red) 2. ‘HU' High Beam (Red-Yellow) 3. ‘HL' Low Beam (Red-White)
1
1. GND (White-Black) 2. Lights Signal (Green)
2
1
1
2
2
1. GND (White-Black) 2. 12V from ‘Cooling Fan' or ‘A/C Fan No.2' Relay (Blue-Black)
1. To ‘A/C Fan No. 2' relay (Blue-White) 2. To ‘Cooler Fan' relay (Blue)
1. White-Green 2. Green-Yellow To HVAC module C-48
Page 9 of 19
91. Horn
92. A/C Compressor
94. FR Park Light
93. FR Main Light & High Beam
1
3
2
95. Windscreen Washer Pump
2 1
1
1
2 2
4 From ‘Horn Relay' (Green-Red)
1. Black-Red 2. Blue-Black 3. Green-Red 4. Yellow-red 5. White-Yellow All wires to HVAC module C-48 97. FR Foglight
96. FR Indicator
3
3
5
1. From ‘Headlights Right' Fuse (Red-Green) 2. ‘HU' High Beam (Red-Yellow) 3. ' HL' Low Beam (Red-White)
1. GND (White-Black) 2. Lights Signal (Green)
1. Rear Washer To C-37 (Blue-White) 2. Front Washer To C-38 (White-Blue) 3. 12V Constant - From ‘Wipers' Fuse (Blue)
1
2 2 1
1. GND (White-Black) 2. ‘TR' (Green-Black)
1. 12V From Fog Light Switch (Red) 2. GND (White-Black)
Connectors plugged into the base of Cream-coloured Cabin Fuse Box
Page 10 of 19
Connector Pinouts & Conduction Details Conduction Code Legend : B1 Battery Source 1 B2 Battery Source 2 F Flasher TB Turn Signal Battery / Power TL Turn Left Signals TR Turn Right Signals B / BI / +B Battery (12V) E / EW Earth/Ground HL Headlight – Low Beam HU Headlight – Upper/High Beam RF Signal to ECU (‘ELS') TI Taillights (and front Park lights) +S Wiper Park/Intermittent +1 Slow/Low Wiper Speed +2 Fast/High Wiper Speed W Washer Pump Diagnostics Connector 53 : Pin Wire Colour FP Blue-White CCO Grey-Green +B Black-Red W N/C TE1 Green-Blue TE2 N/C VF1 Green-Yellow VF2 N/C E1 Brown Ox1 White Ox2 N/C IGBlack AB N/C CC2 N/C TS Red-Blue OPT Red-Yellow TC Red-Black TT N/C Connector 30 : Pin Wire Colour 1 Red-Blue 2 Green-Black 3 Green-Yellow 4 Green-Yellow 5 Red-Yellow 6 Yellow-Red 7 Black 8 Green 9 Green-Red (2Dot) 10 Blue-White 11 Green-White 12 Red-Black 13 Blue-Red 14 Yellow-Black 15 Yellow-Blue 16 Blue 17 Blue-Black 18 Blue-Yellow 19 Green-Red (1Dot)
Connection / Function 12V to Fuel Pump ECU ‘CCO' 12V (via EFI relay) ECU ‘T' ECU ‘VF' ECU ‘E1' (Ground) ECU ‘OX' (Oxygen Sensor) Ignitor Connector 55, Pin 4 Not Connected to anything To HVAC module Not Connected to anything -
O
O : Conduction between pins
Connector 38 : Front Wipers
Connector 32 : Hazard Switch 8 B1
Pin 0003 Switch Position 0001 OFF ON
6 B2
O O
5 F O O
7 TB
O
3 TL
O
4 TR
O
Connector 36 : Ignition Pin 0003 Key Position 0001 LOCK ACC ON START
5 +B
6 +S
1 +1
O
O O
O O
2 +2
3 EW
4 W
O
O
O
Connector 39 : Lights & Indicators
5 AM1
4 ACC
O O O
O O
3 IG1
O O
6 ST1
1 AM2
2 IG2
O
O O
O O
Connector 37 : Rear Wiper Pin 0003 Switch Position 0001 OFF INT ON WASH
Pin 0003 Switch Position 0001 INT LOW HIGH WASH
Pin 0003 Switch Position 0001 OFF
1 I
O O O
O
3 +1
8 TI
O O O O O O
O O O O O O
6 RF
High Beam Flash/Pass Park Lights Main Lights
2 E
9 BI
4 W
High Beam Flash/Pass High Beam Flash/Pass
O O O
1 E
5 HU
O
O
O O O O
O
7 HL
O O O
Connector 39 : Turn Signals O O
Pin 0003 Switch Position 0001 LEFT OFF RIGHT
2 TL
3 TB
O
O O
4 TR
O
Function From ‘Instrument/Dash' Fuse Left Indicator ‘TL' Right Indicator ‘TR' Unknown – From C-63 & C-82 N/C to Engine Bay Loom Handbrake Ground Demister Power Rear Park Lights ‘T' Unknown – From C-63 & C-82 Fuel Pump Rear Brake Lights Reverse Light N/C to Engine Bay Loom Low Fuel Warning Signal Fuel Level Signal Rear wiper power Rear Wiper – Slow speed Rear Wiper – Intermittent N/C to Engine Bay Loom
Page 11 of 19
1
2 3
11
1
5
2
6
3
7
4
8
ABS Fuse Slot
4 5
12
6
ABS Relay Slot
10 9
7 13
8 9 8 10
14 15
Engine Bay Fuse Box 1 AM1 2 A/C Condenser Fan (CDS) 3 Radiator Fan 4 Heater 5 Headlights (Left) 6 Headlights (Right) 7 Interior Dome Light 8 AM2 9 Hazard/Horn 10 EFI 11 Main Relay 12 ‘Cooler' Relay 13 EFI Relay 14 Horn Relay 15 ‘Cooling Fan' Relay
60A 20A 20A 30A 10A 10A 20A 15A 15A 15A -
Cabin Fuse Box 1 Radio 2 Tail Lights 3 Stop Lights 4 N/C 5 Rear Demister 6 Wipers 7 Turn Signals 8 A/C 9 Instrument/Dash Cluster 10 Ignition
10A 15A 10A 30A 20A 7.5A 10A 7.5A 15A
1
2 3 4
Sensors/Switches relating to coolant around thermostat housing : 1 – Connector 68. To HVAC Module 2 – Connector 71. To ECU 3 – Connector 70. To Dash Gauge 4 – Connector 69. Temperature Switch for Radiator Fan Radiator Fan Switch (4) has internal switch : Conduction when Coolant < 93°C No Conduction when Coolant > 93°C
Page 12 of 19
Relay Connection & Pin Details 5 1
1
2
3
#11 Main Relay (N/O)
2
4
3
4
1. Ignition ‘IG2' (Black-Red) 2. GND (White-Black) 3. ‘AM1' Fuse (White) 4. Radiator Fan Fuse (White-Red)
1
A/C Fan No.2 Relay
4
1
3
2 2
4
5
3 Part # 90987-02006
1. ‘Cooling Fan' Relay Pin 1 & C-85 A/C Pressure Switch (Light Green-Red) 2. Ignition ‘IG2' (Black-Red) 3. A/C Fan No. 3 Relay Pin 3 (Blue-Red) 4. GND (White-Black) 5. Radiator Fan (Blue-Black) Pins 3 & 4 are shorted when coil is not energized Part # 90987-02010
1 N/C
2
1
3
2
4
#12 ‘Cooler' Relay (N/O)
4
3
1. Ignition ‘IG2' (Black-Red) 2. GND (White-Black) 3. C-89 - A/C Fan (Blue) 4. CDS Fan Fuse (Blue-Black) Part # 90987-04002
5
A/C Fan No.3 Relay (N/O)
1
1
3
2
5
2 3
4
2
1
2
3
4
#13 EFI Relay (N/O) 22 Amp rating
3
Part # 90987-02004
1
1
Power Windows Relay (N/O) 22 Amp rating
1
#14
4
2
3
1
3
3
Body GND
1. C-91 – Horn (Green-Red) 2. Horn Fuse (Green-White) 3. C-39 - Horn button (Green-Yellow) Part # 86530-20070
Circuit Opening Relay (N/O) (Connector 1)
2
1
1
3
2
4
#15 4
1
2
3
4
1. From Power Windows Fuse (Blue) 2. C-22 Door Control Module (Red-Green) 3. To Power Window (Blue-Green) 4. GND (White-Black) Part # 90987-02004
4
5 3
3
1
2
5
‘Cooling Fan' Relay (N/C) 15 Amp rating
Part # 90987-04003
2 2
Horn Relay (N/O)
1. EFI Fuse (White-Red) 2. Ignition ‘IG2' (Black-Red) 3. C-1 – Circuit Opening Relay Pin 2 (Black-Red) 4. GND (White-Black)
1. GND (White-Black) 2. C-48 – HVAC (Black-Blue) 3. A/C Fan No. 2 Relay Pin 3 (Blue-Red) 5. A/C Condenser Fan (Blue-White)
3
1. To Fuel Pump (Blue-White) 2. 12V from ‘EFI' Relay & ECU ‘BATT' (Black-Red) 3. From Ignition ‘ST1' & To Starter Motor solenoid & ECU ‘STA' 4. To ECU ‘FC' (Fuel Cut) 5. GND (White-Black) Part # 85910-10010
4 1. A/C Fan No. 2 Relay Pin 1 & C-85 A/C Pressure Switch (Light Green-Red) 2. Ignition ‘IG2' (Black-Red) 3. Radiator Fan Fuse (White-Green) 4. A/C Fan No. 2 Relay Pin 5 & Radiator Fan (Blue-Black) N/C Relay - Pins 3 & 4 are shorted when coil is not energized
2
1
N.B. Diagrams are of relay plugs as viewed from above fuse box, not underside of actual relays Page 13 of 19
Instrument/Gauge cluster layout & PCB
Battery Charge
TEMS
Note : photos are from 1991 (Gen 1) M/T 4E-FTE with no ABS or TEMS
Handbrake
O/D
ABS
ABS, TEMS & A/T Overdrive LED/light locations have been indicated
Low Oil Pressure
Catalytic Converter Overheat
Check Engine
A/T Connector
12V
White Connector
High Beam
GND GND
12V GND
Boost Pressure Gauge Sub-Harness (connects between instrument cluster & cabin wiring loom)
Blue Connector
12V
GND
GND 12V
IG+
IG+
Tacho Signal IG+
12V GND
GND
GND IG+
IG+ GND
IG+ GND
12V GND
GND GND
GND IG+
GND 12V
IG+
Signal
GND
Speedo Signal
IG+ GND
IG+
GND
Signal
IG+
Black 4 pin Connector (Boost Pressure Gauge) Sub-Harness Page 14 of 19
Instrument/Gauge cluster wiring B2 B5
Fuel Gauge
B3
Temperature Gauge Lights (Positive)
A1
Green ‘T'
Battery Charge (Positive)
A2
Black-Red ‘IG2'
Handbrake Light (Ground)
A3
Yellow-Red
Battery Light (Ground) from Alternator
A4
Mustard-Black (1 Silver dot on wire)
TEMS ‘N' (Power)
A5
Pink-White
Tacho Signal (IG-)
A6
White
TEMS S' (Power)
A7
Pink-Black
Oil Pressure Light (Ground)
A8
Mustard
Cat Converter Overheat (Ground)
A9
Grey-Black (ECU Pin ‘EGW')
Engine Check Light (Ground)
A12
Tacho A6
B6
Speedo O/D Off
A11
Oil Pressure
A8
Handbrake
A3
A10 Green-White (ECU Pin ‘W')
O/D OFF (Ground)
Exhaust Temperature
A11 Red-Yellow
Temperature Gauge Signal
A12 Yellow-Green A2
A9
Battery Charge
A4
Engine Check Fuel Level Warning Light (Ground)
B1
Mustard-Black (2 Silver dots on wire)
Fuel Level Gauge Signal
B2
Mustard-Blue
Ignition (From ‘Dash' Fuse)
B3
Red-Blue
ABS (Ground)
B4
Red-Yellow (2 Silver dots on wire)
Ground (Gauges only)
B5
Brown
Speedo Signal
B6
Yellow-Blue (ECU Pin ‘SPD')
Ground (Indicators & Lights)
Fuel Level Warning
B7
White-Black
B8
Green-Black
High Beam 12V (From ‘H/Lights Right' Fuse)
B9
Red-Green
High Beam (Ground)
ABS
B11 Green-Yellow
A/T Reverse
B11
B8
B7 Right Indicator
Left Indicator Green
A5
TEMS (N) Amber
A7
B12 Red-Black A1 B9
2 Mode (Lo/Hi Boost)
D1
Yellow
Ground
D2
Black
Signal
D3
Blue
Ignition (IG+)
D4
Red
Automatic Transmission Connector – C1 & C2
B4
C2
B10 Red-Yellow (1 Silver dot on wire) ‘HU'
RHS Indicator (Power)
B1
B12
C1
LHS Indicator (Power)
A10
D2
TEMS (S) Illumination High Beam Lo/Hi Boost Indicator
2 Mode Turbo Gauge
B10 D3 D1 D4
Page 15 of 19
NOTE : The details on this page have been sourced from publicly accessible PDF detailing all EP82 & EP91 ECU's and pinouts http://street-legal-starlet.nl/Sagittarius/ecu's.pdf. The details are copyrighted to StreetLegalStarlet forums http://www.streetlegal-starlet.nl/forum/, documented by Sagittarius®. These details are taken as a screenshot of the single PDF page relating to the Gen1 (Dec 1989 – Jan 1992) EP82 Toyota Starlet GT. ECU details for later models can be obtained from the PDF.
Page 16 of 19
NOTE : The details on this page have been sourced from publicly accessible JPG detailing the EP82 (Zenki) ECU wiring diagram. The original JPG is copyrighted to StreetLegalStarlet forums http://street-legal-starlet.nl/Sagittarius/Wiring/SLS%20%20EP82%20Wiring%20diagram%20%28zenki%29.jpg. Corrections made to the original JPG : ‘VF' Pin number corrected from CON-1 Pin 15 to 16; CON-2 Pin 7 ‘BC' added; Coil input for Main EFI relay moved from ‘ST1' to ‘IG2' line Lo/Hi Boost Switch
BC 7
CON-2
16
CON-1
Page 17 of 19
Power Windows
B-Y
Alternator Y-B
Dash Battery Light
Battery (12V)
G-W
‘B'
G
‘T'
Window Motors
2
4
W-B
Clock R-G
Cigarette Lighter
G-R
1 L-G
Clock Instrument Cluster Radio
Brake Pedal Switch
Stop Lights
3
Radio
Rear Lights
AM1 W
L
G
Light Control Switch
Tail Lights
'Dash' Fuse
Fog Lights R
W-B
R-B
W
Fog Light Switch
Front Park Lights
Power Windows Relay
G-W
Door Control Module
Relay – Light Reminder
Radio GR
L-R
Ignition Switch
Power Windows Control Buttons
Legend : W : White B : Black G : Green GR : Grey LG : Light Green L : Blue P : Pink Y : Yellow O : Orange BR : Brown eg. W-R : White wire, Red trace
ACC
W-L
AM1
Power Mirrors Control Buttons
IG1
B-Y
ST1
B-W
Rear Demister
AM2 W-R
AM2
IG2
B-Y
W
Ignitor
H/Lights Left
Low Beam
B-W
Relay Light Reminder
H/Lights Right
Injectors 1 & 3 G GR
R-W ‘HL' ‘E' W-B
High Beam
R-Y
‘T' Lights
R-B
Low Beam Dash High Beam Light
Injectors 2 & 4
ECU CON-1 ‘#10'
From ‘Radio' Fuse
‘HU'
R-G
High Beam
Demister
L-Y L-B L-O
L
Front Washer B-Y
W-L
From ‘Dash' Fuse
R-W
L-Y
Y-L
Fuel Level Sender
Check Engine Light
G-W
ECU CON-2 ‘W'
GR-B
ECU CON-2 ‘EGW'
L-W
B
B-R
Battery
Ignition
Manual Roof Switch
Fuel Level Warning Light
Rear Washer Starter Motor
RHS Door Switch
Wiper motor
Wiper Switch
Wipers
ECU CON-1 ‘#20'
R-G
Dome
B
Coil
Light Control Switch
R
Single wire Multiple wires
Demister Switch LG
B-R
B-R
Power Mirrors
LHS Door Switch
L-G
TEMS Module
W-B
Exhaust Temp Light
R-B
R-W
EFI Relay 2
Reverse Switch 4
W-B
3
W-B 2
5
Horn Button
3
GR-Y
1
GR-R
2
3
B
4
G
1
L-W
Fuel Pump
2
1
W-B
L W-B
A/C Condenser A/C Pressure Fan Switch
‘F'
Left Indicators
L-W
Dash Left Lamp
Coolant Temp Switch LG
LG-R
A/C Fan No. 2
‘Cooling Fan' Relay 2
1
1
2
B-R
LG
W-G
LG-R
1
4
W-R
4
W-G 3
L-B
5
W-G
2
W-B 3
L-R
W-B 4
Dash Fan Switch Lo/Med/Hi
Heater L-W
Fan/Blower
L-R
Left Indicators A/C Compressor
HVAC Module
A/C Fan No. 3
B-R
Rad Fan 3
‘TB'
‘B1'
LG-R
Main Relay
‘TL'
A/C
‘Cooler' Relay 3
GR GR-Y
‘TR' ‘B2'
4
‘TL' ‘TR'
‘TB'
Turn
Horn
B-R
L-B
Y-R
Turn Signal Switch
Hazard Switch
ECU CON-2 ‘FC'
R-L
CDS Fan
Dash Handbrake Light
W-B
Handbrake
Circuit Opening Relay (Connector 1)
ECU CON-2, ‘+B1'
Horn Relay G-W
Relay – Light Reminder
B-R
ECU CON-2, ‘BATT'
Haz/Horn
Low Brake Fluid Switch Y-R
R-B 1
Y
Dash
EFI W-R
Oil Pressure Switch
Oil Pressure Light
ECU CON-1, ‘STA'
3
5
1
2
G-Y B-L A/C On/Off Signal
L-Y G-R
Radiator Fan
W-B
Idle Up Valve
G-L
B-Y
Vacuum Switch Valve
Ambient Temp Sensor Coolant Temp Sensor
Dash Right Lamp
Flasher Relay GR-L W-B
Page 18 of 19
A/C Condenser Fan & Radiator Fan Relay Configurations ‘AM1'
This page details the current flow through the relay coils and switches in various configurations
‘IG2'
Legend : Coil Energised Current Flow through relay coils Current Flow through relay contacts
‘Cooler' Relay
CDS Fan
A/C Condenser A/C Pressure Fan Switch
Main Relay
‘Cooling Fan' Relay
Coolant Temp Switch
A/C Fan No. 2
A/C Fan No. 3
HVAC Module
A/C On/Off Signal
Rad Fan
• • • •
Ignition On A/C Off Normal Coolant Temperature Normal A/C Pressure
No fans running
Radiator Fan
‘AM1'
‘IG2' ‘Cooler' Relay
CDS Fan
A/C Condenser A/C Pressure Fan Switch
‘Cooling Fan' Relay
Main Relay
Coolant Temp Switch
A/C Fan No. 2
A/C Fan No. 3
HVAC Module
A/C On/Off Signal
Rad Fan
• • • •
Ignition On A/C On Normal Coolant Temperature Normal A/C Pressure
Both fans powered in series and both run at low speed
Radiator Fan
‘AM1'
‘IG2' ‘Cooler' Relay
CDS Fan
A/C Condenser A/C Pressure Fan Switch
‘Cooling Fan' Relay
Main Relay
Coolant Temp Switch
A/C Fan No. 2
A/C Fan No. 3
HVAC Module
• • •
Ignition On A/C On High Coolant Temperature or High A/C Pressure
Fans powered in parallel through separate fuses and run at high (full) speed A/C On/Off Signal
Rad Fan Radiator Fan
‘AM1'
‘IG2' CDS Fan
‘Cooler' Relay A/C Condenser A/C Pressure Fan Switch
Main Relay
‘Cooling Fan' Relay
Coolant Temp Switch
A/C Fan No. 2
A/C Fan No. 3
HVAC Module
A/C On/Off Signal
Rad Fan
• • • •
Ignition On A/C Off High Coolant Temperature Normal A/C Pressure
A/C Condenser fan not running. Radiator Fan runs as high (full) speed
Radiator Fan
Page 19 of 19